污泥比阻設計實驗報告

環境工程專業學生設計性實驗報告實驗課程名稱 混凝劑（硫酸鋁）與污泥反應時間的不同對污泥比阻的影響指導教師 董春欣 姓名孫鏡偉 學號12310113 專業環境工程 班級環工1201 摘要:根據長期實驗教學中所取得的經驗,對污泥比阻實驗中幾個參數的確定和經常碰到的一些問題,提出了自己的看法和解決的辦法,為比阻實驗的可操作性提供了幫助?；炷齽┓N類繁多，如何根據水處理廠工藝條件、原水水質情況和處理后水質目標選用合適的混凝藥劑，是十分重要的污泥比阻作為反映污泥脫水性能 的主要參數,是水廠生產廢水調質及脫水工藝的重要控制指標.指出了常規污泥比阻抽濾測定方法中存在的測定指標多、操作復雜、測定歷時長等問題.針對自來水 廠生產廢水的水質特點,根據污泥比阻的測定理論。關鍵詞:混凝劑；污泥比阻;過濾;脫水性能等Abstract:Thedeterminationofseveralparametersinthesludgeandproblemsusuallyoccurredintheexperimentwerediscussedandroperationonlaboratorymeasure2mentofsludgespecificresistance.with the enlargement of our country resently,Urban sewage is an enormous quantity of low concentration organic wastewater. In this paper, the urban sewage treatment technology and main structure design in an all-round way. Including the grille, collecting well, sewage pump room, sedimentation tank, adjusting pool, aeration tank, and the concentrated tank, etc. Key words:concentration organic wastewater. In this paper, the urban sewage treatment technology and main 10一、實驗方案實驗名稱： 混凝劑（硫酸鋁）與污泥反應時間的不同對污泥比阻的影響實驗時間：小組合作：是 否小組成員： 一、實驗?zāi)康模海?）通過實驗掌握污泥比阻的測定方法。（2）掌握用布氏漏斗實驗選擇混凝劑。（3）掌握確定污泥的最佳泥凝劑投加量。（4）測定混凝劑(硫酸鋁)反應時間對污泥比阻的影響。二、實驗設備與材料：（1）實驗設備：(1)實驗裝置如圖2。圖2 比阻實驗裝置圖1真空泵；2吸濾瓶；3真空調節閥；4真空表；5布式漏斗；6吸濾墊；7計量管(2)秒表；濾紙。(3)烘箱。(4)A12(SO4)3。(5)布氏漏斗。(6)100ml量筒（2）實驗材料：A12(SO4)3(10g/L)三、實驗方法步驟及注意事項（1）實驗方法步驟：1.測定污泥的含水率，求出其固定濃度C0。2.配制A12(SO4)3(10g/L)混凝劑。3. 用A12(SO4)3混凝劑調節污泥(每組加一種混凝劑)，加量為干污泥質量的6。放置5分鐘后進行抽濾。，用水潤濕，貼緊周底。5.開動真空泵，調節真空壓力，大約比實驗壓力小1/3實驗時真空壓力采用266mmHg(3546kPa)或532mmHg(704. 在布氏漏斗上(直徑6580mm)放置濾紙93kPa)關掉真空泵。6. 加入l00mL需實驗的污泥于布氏漏斗中，開動真空泵，調節真空壓力至實驗壓力；達到此壓力后，開始起動秒表，并記下開動時計量管內的濾液V0。7. 分別記下0s、10s、20s、30s、60s、90s、120s.計量管內相應的濾液量。8.一直過濾至真空破壞，如真空長時間不破壞，則過濾20min后即可停止。9.關閉閥門取下濾餅放人稱量瓶內稱量。10.稱量后的濾餅干105的烘箱內烘干稱量。11. 計算出濾餅的含水率，求出單位體積濾液的固體量C0。12.將A12(SO4)3混凝劑與污水混合，分別放置10分鐘、15分鐘、20分鐘、25分鐘，再分別進行上5-11的實驗步驟。（2）注意事項：1. 檢查計量管與布氏漏斗之間是否漏氣。2.濾紙烘干后稱量，放到布氏漏斗內，要先用蒸餾水濕潤，而后再用真空泵抽吸一下，濾紙要貼緊不能漏氣。3. 污泥倒入布氏漏斗內時，有部分濾液流入計量筒，所以正常開始實驗后記錄量筒內濾液體積。4 .污泥中加混凝劑后應充分混合。5.在整個過濾過程中，真空度確定后始終保持一致。四、實驗數據處理方法：（1）測定并記錄實驗基本參數，記錄格式如下。實驗日期 ；原污泥的含水率及固體濃度C0。實驗真空度/mmHg ；不加混凝劑的濾餅的含水率加混凝劑濾餅的含水率（2）將布氏漏斗實驗所得數據按表1記錄并計算。（3）以t/V為縱坐標，以V為橫坐標作圖，求。（4）根據原污泥的含水率及濾餅的含水率求出C0（5）列表計算比阻值（見表2比阻計算表）（6）以比阻為縱坐標，反應時間為橫坐標，作圖求出最佳投加量C的求法。根據所設定義 5、參考文獻：污泥脫水性能參數比阻檢測的若干問題研討污泥比阻實驗中幾個問題的探討改善城市污水廠污泥脫水性能的試驗研究不同混凝劑對污泥脫水性能的影響研究硫酸鋁作為混凝劑時絮體破碎與再絮凝的研究二、實驗報告1、實驗現象、數據及結果混凝時間為5分鐘tVV-V0t/V-V0025.00 0.00 030.00 1068.33 43.33 0.23076923182.00 2090.83 65.83 0.303797468109.00 30101.67 76.67 0.391304348122.00 60109.17 84.17 0.712871287131.00 90110.00 85.00 1.058823529132.00 120110.83 85.83 1.398058252133.00 180111.67 86.67 2.076923077134.00 240111.67 86.67 2.769230769134.00 300111.67 86.67 3.461538462134.00 360111.67 86.67 4.153846154134.00 420111.67 86.67 4.846153846134.00 480111.67 86.67 5.538461538134.00 540111.67 86.67 6.230769231134.00 600111.67 86.67 6.923076923134.00 660111.67 86.67 7.615384615134.00 720111.67 86.67 8.307692308134.00 780111.67 86.67 9134.00 840111.67 86.67 9.692307692134.00 900111.67 86.67 10.38461538134.00 960111.67 86.67 11.07692308134.00 1020111.67 86.67 11.76923077134.00 1080111.67 86.67 12.46153846134.00 1140111.67 86.67 13.15384615134.00 1200111.67 86.67 13.84615385134.00 混凝時間為10分鐘tVV-V0t/V-V0013.33 0.00 016.00 1036.67 23.34 0.42851021344.00 2060.00 46.67 0.42854081972.00 3076.67 63.34 0.47365928192.00 60106.67 93.34 0.642834184128.00 90110.00 96.67 0.931002379132.00 120110.00 96.67 1.241336506132.00 180110.83 97.50 1.846090732133.00 240111.67 98.34 2.440595234134.00 300111.67 98.34 3.050744043134.00 360111.67 98.34 3.660892851134.00 420111.67 98.34 4.27104166134.00 480111.67 98.34 4.881190468134.00 540111.67 98.34 5.491339277134.00 600111.67 98.34 6.101488085134.00 660111.67 98.34 6.711636894134.00 720111.67 98.34 7.321785702134.00 780111.67 98.34 7.931934511134.00 840111.67 98.34 8.542083319134.00 900111.67 98.34 9.152232128134.00 960111.67 98.34 9.762380936134.00 1020111.67 98.34 10.37252974134.00 1080111.67 98.34 10.98267855134.00 1140111.67 98.34 11.59282736134.00 1200111.67 98.34 12.20297617134.00 混凝時間為15分鐘tVV-V0t/V-V008.33 0.00 010.00 1016.67 8.34 1.19952019220.00 2041.67 33.34 0.59994000650.00 3058.33 50.00 0.59996000370.00 6093.33 85.00 0.705854672112.00 90107.50 99.17 0.90753252129.00 120108.33 100.00 1.199960001130.00 180110.00 101.67 1.770433756132.00 240110.83 102.50 2.341387272133.00 300111.67 103.34 2.903132157134.00 360111.67 103.34 3.483758588134.00 420111.67 103.34 4.06438502134.00 480111.67 103.34 4.645011451134.00 540111.67 103.34 5.225637883134.00 600111.67 103.34 5.806264314134.00 660111.67 103.34 6.386890745134.00 720111.67 103.34 6.967517177134.00 780111.67 103.34 7.548143608134.00 840111.67 103.34 8.12877004134.00 900111.67 103.34 8.709396471134.00 960111.67 103.34 9.290022902134.00 1020111.67 103.34 9.870649334134.00 1080111.67 103.34 10.45127577134.00 1140111.67 103.34 11.0319022134.00 1200111.67 103.34 11.61252863134.00 混凝時間為20分鐘tVV-V0t/V-V006.67 0.00 08.00 1051.67 45.00 0.22223868462.00 2075.00 68.33 0.29269720590.00 3090.00 83.33 0.360014401108.00 60108.33 101.66 0.590183285130.00 90110.00 103.33 0.870995839132.00 120110.83 104.16 1.152036865133.00 180111.67 105.00 1.714340138134.00 240111.67 105.00 2.28578685134.00 300111.67 105.00 2.857233563134.00 360111.67 105.00 3.428680276134.00 420111.67 105.00 4.000126988134.00 480111.67 105.00 4.571573701134.00 540111.67 105.00 5.143020413134.00 600111.67 105.00 5.714467126134.00 660111.67 105.00 6.285913839134.00 720111.67 105.00 6.857360551134.00 780111.67 105.00 7.428807264134.00 840111.67 105.00 8.000253976134.00 900111.67 105.00 8.571700689134.00 960111.67 105.00 9.143147402134.00 1020111.67 105.00 9.714594114134.00 1080111.67 105.00 10.28604083134.00 1140111.67 105.00 10.85748754134.00 1200111.67 105.00 11.42893425134.00 混凝時間為25分鐘tVV-V0t/V-V0011.67 0.00 014.00 1050.00 38.33 0.26089225260.00 2073.33 61.66 0.32434185688.00 3090.00 78.33 0.382995021108.00 60108.33 96.66 0.620711059130.00 90110.00 98.33 0.915285264132.00 120110.00 98.33 1.220380352132.00 180110.00 98.33 1.830570528132.00 240110.00 98.33 2.440760704132.00 300110.00 98.33 3.05095088132.00 360110.00 98.33 3.661141056132.00 420110.00 98.33 4.271331232132.00 480110.00 98.33 4.881521408132.00 540110.00 98.33 5.491711583132.00 600110.00 98.33 6.101901759132.00 660110.00 98.33 6.712091935132.00 720110.00 98.33 7.322282111132.00 780110.00 98.33 7.932472287132.00 840110.00 98.33 8.542662463132.00 900110.00 98.33 9.152852639132.00 960110.00 98.33 9.763042815132.00 1020110.00 98.33 10.37323299132.00 1080110.00 98.33 10.98342317132.00 1140110.00 98.33 11.59361334132.00 1200110.00 98.33 12.20380352132.00 混凝時間（min)510152025原始干污泥質量 g2.8773F 過濾面積38.465cm²0.0038465m²P 推動力（kpa)35.46混凝劑6%b值0.04150.02290.01270.01790.0157T 13.513.5131313燒杯+濾紙 g87.440389.825393.138791.364594.9223燒杯+濾紙+濕濾餅 g91.013294.81898.596.3902100.3702燒杯+濾紙+干泥餅 g87.752890.419793.748692.005695.567濕泥質量 g3.57294.99275.36135.02575.4479干泥質量 g0.31250.59440.60990.64110.6447Ci0.0031250.0059440.0060990.0064110.006447Cf8.74639648511.9053818611.3759722512.7564319411.83391766100-Ci99.99687599.99405699.99390199.99358999.993553100-Ci/Ci3199916822.6877516395.1305115597.1906115510.09043100-Cf91.2536035288.0946181488.6240277587.2435680688.16608234100-Cf/Cf10.433287.3995625847.7904574526.8391826557.450286955100-Ci/Ci-100-Cf/Cf31988.5667216815.2881916387.3400615590.3514315502.64014C值 1/100-Ci/Ci-100-Cf/Cf3.12612E-055.94697E-056.10227E-056.41422E-056.45051E-051+0.0337*T+0.000221T²1.495227251.495227251.4754491.4754491.475449µ值0.00178/1+0.0337*T+0.000221T²0.0011904540.0011904540.0012064120.0012064120.001206412b/C1327.525519385.0700995208.1192187279.0672905243.39145022PF²1049301272PF²/µ8814291305488142913054869769949178697699491786976994917=2PF²/µ*b/c1.17012E+143.39412E+131.81016E+132.42724E+132.11695E+13混凝劑 g17.317.317.317.317.3 2、結論：在100mL污泥中，加入17.3mLA12(SO4)3（10g/l）混凝劑，設計混凝時間為5min、10min、15min、20min、25min，隨著混凝時間的延長，混凝效果顯著，污泥比阻逐漸下降。指導教師對實驗結果意見：指導教師簽名：年 月 日